2004 Ford Pickup

//2004 Ford Pickup

2004 Ford Pickup

Ford Pickup

Mileage
121,488
Service Date
6/30/2020
Services Performed
  • BRAKES APPROX FRONT 4 MM APPROX REAR 8 MM TIRES FRONT 9 /32in REAR 9 /32in FLUIDS LEVEL AND CONDITION, ok BATTERY CONDITION, ok 760-850 WIPER / WASHER FLUID, ok CHECK LIGHTS, ok CHECK A/C SYSTEM, ok now CHECK ELECTRONICS, ok
  • LOCK FOR SPARE TIRE HOLE/TOOL WAS STUCK , LUBRICATED IT AND EASY TO RELEASE NOW .
  • PERFORMED OIL CHANGE AND MULTI-POINT INSPECTION
  • RECOVERED 418 KG OF FREON , MACHINED DID VACUUM TEST FOR 20 MINS , SYSTEM HOLD VACUUM OK , INSTALLED NEW CORE VALVES ON BOTH LINES , RECHARGED A/C SYSTEM WITH 960KG OF FREON , A/C BLOWING COLD WITHIN SPECS AT THIS TIME , ADDED DYE TO SYSTEM IF IT GETS LOW AGAIN WE WILL ABLE TO TRACE ANY POSSIBLE LEAKS
  • REPLACED ALL 8 SPARK PLUGS , CYLINDER # 3 BROKE DURING REMOVAL ( NORMAL DUE TO FAULTY DESIGN ) , NEEDED TO BE REMOVED WITH SPECIAL EXTRACTOR , INSTALLED ALL NEW SPARK PLUGS INSTALLED NEW COIL BOOT ON CYLINDER # 7 DUE TO FAULTY BOOT , ROAD TESTED VEHICLE AFTER REPAIR , DRIVES SMOOTHER THAT BEFORE . NOTE : ALL COIL WORKING OK BUT BASE ON VISUAL INSPECTION THEY MAY NEED REPLACEMENT ON NEAR FUTURE.
  • REPLACED BOTH LICENSE PLATE LIGHTS BULBS AND CENTER BRAKE LIGHT
  • REPLACED BOTH SIDE AXLE SEAL DUE TO PASSENGER SIDE LEAK , CLEANED PARKING BRAKE SHOES MINOR CONTAMINATION , REPLACED YOKE AND REAR COVER SEAL/GASKET , ADDED NEW DIFFERENTIAL FLUID , ROAD TESTED VEHICLE OK AT THIS TIME. NOTE : CLEANED OLD RESIDUAL OIL AS BEST AS POSSIBLE BUT STILL SHOWING SOME OLD RESIDUAL OIL AROUND DIFFERENTIAL
  • REPLACED DRIVE BELT DUE TO CRACKS , OK AT THIS TIME.
  • REPLACED ENGINE AIR FILTER DUE TO EXCESSIVE CONTAMINATION
  • REPLACED FRONT LOWER CONTROL ARMS DUE TO EXCESSIVE WEAR ON BALL JOINTS AND WEAR ON CONTROL ARM BUSHINGS AS WELL , THERE WAS A CLUNKING NOISE PRIOR TO REPAIR , NO MORE NOISE AFTER REPAIR . BIG O TIRES PERFORMED 4 WHEEL ALIGNMENT AFTER CONTROL ARM REPAIR .
  • TESTED A/C SYSTEM AND IT WAS WEAK , CHECKED PRESSURE WAS LOW , RECOMMEND TO PERFORM A/C CYCLE , RECOVER , VACUUM AND RE-CHARGE , REPLACED CORE VALVES AND ADD DYE TO SYSTEM TO TRACE ANY POSSIBLE LEAK .
  • VERIFIED REAR DIFFERENTIAL LEAK AT THE CENTER YOKE SEAL , REAR COVER GASKET AND PASSENGER SIDE AXLE SEAL , RECOMMEND TO REPLACE AND SERVICE REAR DIFFERENTIAL .
  • BIG O TIRES PERFORMED 4 WHEEL ALIGNMENT
 
MIKE B. gave our service a 5 star review on 6/30/2020
2020-07-01T22:01:48+00:00